پیوندهای مفید
اخبار و اعلانات
آمار
| تعداد نشریات | 158 |
| تعداد شمارهها | 6,230 |
| تعداد مقالات | 67,764 |
| تعداد مشاهده مقاله | 115,151,390 |
| تعداد دریافت فایل اصل مقاله | 89,910,113 |
Investigating the Effect of Compaction Level and Aggregate Grading of Stone Materials in Base Layer on Bitumen Penetration Rate | ||
| Civil Engineering Infrastructures Journal | ||
| دوره 55، شماره 2، اسفند 2022، صفحه 395-405 اصل مقاله (374.63 K) | ||
| نوع مقاله: Technical Notes | ||
| شناسه دیجیتال (DOI): 10.22059/ceij.2021.317415.1737 | ||
| نویسندگان | ||
| Ahmad Goli* 1؛ Hooman Hooshangi2؛ Mohammadjavad Kazemi3 | ||
| 1Assistant Professor, Department of Civil and Transportation Engineering, University of Isfahan, Isfahan, Iran. | ||
| 2M.Sc., Graduate Research Assistant, Eskan Deh Road Construction Company, Isfahan, Iran. | ||
| 3Ph.D. Student, Civil Engineering, Arizona State University, Tempe, USA. | ||
| چکیده | ||
| One of the layers that is applied on the base layer in asphalt pavements and increases the cohesion between the two layers, is the prime coat layer. Due to the fact that there are usually problems with the prime coat penetration into the base layer and penetration is not usually done well, there is a need to identify the factors affecting the penetration into the base layer. In this study, the penetration rate of prime coat coatings made of emulsified bitumen CSS-1h on the grain base level with different aggregate grading (aggregation close to the lower, middle and upper limits in two different types of aggregate grading) and different compaction levels were examined. Optimum water content, density, California Bearing Ratio (CBR) and the permeability of the samples were also examined. According to the results, the compressive strength of stone materials samples increases with approaching the upper limit (fine grain) and increasing the compaction. Also, increasing the grain size and decreasing compaction, increases the prime coat penetration rate, so that the 90% compacted sample with aggregate grading Type 3 has the highest penetration rate. The effect of moisture is obvious on the prime coat penetration, so that prime coat penetration rate is greatly reduced in saturation mode, but moisture in the base layer can help the prime coat to penetrate into the base layer. | ||
| کلیدواژهها | ||
| Aggregate Grading؛ Base Layer؛ Compaction؛ Emulsified Bitumen؛ Penetration؛ Prime Coat | ||
| مراجع | ||
|
AASHTO T99-10 Standard. (2015). 99: Moisture-density relations of soils using a 2.5-kg (5.5-lb) rammer and a 305-mm (12-1 in.) drop, Standard Specifications for Transportation Materials and Methods of Sampling and Testing 2.
AASHTO (2013). Sizes of aggregate for road and bridge construction (M 43-05), AASHTO, Washington, DC.
ASTM, D. (2000). 1557: Standard test methods for laboratory compaction characteristics of soil using modified effort (56,000 ft-lbf/ft3 (2,700 kN-m/m3)), Annual Book of ASTM Standards, ASTM International, West Conshohocken, PA, United States.
ASTM, D1883-16 (2016). Standard test method for California bearing ratio (CBR) of laboratory-compacted soils, West Conshohocken, PA, United States.
Bastidas-Martínez, J.G., Ruge, J.C., Paba, I.J., Vasquez, F. and Rojas Suárez, J.P. (2020). “Physical mechanical performance of asphaltic emulsions in road oil for flexible pavements“, Journal of Physics: Conference Series, 1645, 012011.
Behbahani, H., Hamedi, G.H. and Najafi Moghaddam Gilani, V. (2020). “Predictive model of modified asphalt mixtures with nano hydrated lime to increase resistance to moisture and fatigue damages by the use of deicing agents“, Construction and Building Materials, 265, 120353.
Chhorn, C. and Lee, S.W. (2018). "Influencing compressive strength of roller-compacted concrete", Proceedings of the Institution of Civil Engineers - Construction Materials, 171(1), 3-10.
Chun, S., Kim, K., Park, B. and Greene, J. (2017). "Evaluation of structural benefits of prime coat application for flexible pavements using accelerated pavement testing (APT)", KSCE Journal of Civil Engineering, 21(1), 141-149.
Cross, S.A., Voth, M.D. and Shrestha, P.P. (2005). “Guidelines for prime coat usage on low-volume roads“, Transportation Research Record, 1913(1), 117-125.
Freeman, T.J., Button, J.W. and Estakhri, C.K. (2010). "Effective prime coats for compacted pavement bases", No. FHWA/TX-10/0-5635-1. 2010.
Hu, X., Lei, Y., Wang, H., Jiang, P., Yang, X. and You, Z. (2017). "Effect of tack coat dosage and temperature on the interface shear properties of asphalt layers bonded with emulsified asphalt binders", Construction and Building Materials, 141, 86-93.
Huang, Y.H. (2004). Pavement analysis and design, Second Edition, Pearson Publication.
Ishai, I. and Livneh, M. (1984). “Functional and structural role of prime coat in asphalt pavement structures“, In: Association of Asphalt Paving Technologists Proceedings, Vol. 53, 98-118.
Kucharek, A.S., Eng, P., Scarborough, O., Davidson, J.K. and Kennedy, M. (2008). "Development of a solvent-free asphalt emulsion for prime coats and granular sealing", In: Proceedings of the Fifty-third Annual Conference of the Canadian Technical Asphalt Association (CTAA) Canadian Technical Asphalt Association (CTAA), 84-102.
Mantilla, C.A., and Button, J.W. (1994). Prime coat methods and materials to replace cutback asphalt, Technical Report, Report No. FHWAffX-94/1334-lF, U.S. Department of Transportation, Virginia.
Mohan, G., Yildirim, Y., StokoeII, K.H. and Erten, M.B. (2013). "Engineering properties of prime coats applied to a granular base", Journal of Testing and Evaluation, 41(5), 713-718.
Motamedi, H., Amiri, H.R., Fazaeli, H. and Mohammad Aliha, M.R. (2021). "Providing a prediction model for stress intensity factor of fiber-reinforced asphalt mixtures under pure mode III loading using the Edge Notched Disc Beam (ENDB)", Civil Engineering Infrastructures Journal, 54(1), 43-58.
Ouyang, J., Sun, Y. and Zarei, S. (2020). "Fabrication of solvent-free asphalt emulsion prime with high penetrative ability", Construction and Building Materials, 230, 117020.
Šernas, O., Zofka, A., Vaitkus, A. and Gražulytė, J. (2020). "The effect of exposed aggregate concrete gradation on the texture characteristics and durability", Construction and Building Materials, 261, 119921.
Slaughter, G. (2004). "Environmental comparison of cutback bitumen and bitumen emulsions for sealing roads", Towards Sustainable Land Transport Conference, Wellington, New Zealand.
Standard, A.A.S.H.T.O. (2009). T265: Standard method of test for laboratory determination of moisture content of soils, Standard Specifications for Transportation Materials and Methods of Sampling and Testing. American Association of State Highway Officials, Washington.
Taherkhani, H. (2016). "Investigating the effects of nanoclay and nylon fibers on the mechanical properties of asphalt concrete", Civil Engineering Infrastructures Journal, 49(2), 235-249.
Taherkhani, H. and Afroozi, S. (2017). "Investigating the performance characteristics of asphaltic concrete containing nano-silica", Civil Engineering Infrastructures Journal, 50(1), 75-93.
Transportation Officials. (1993). AASHTO Guide for design of pavement structures, Vol. 1, Aashto. Washington.
Vignarajah, M., Leaverton, M. and Senadheera, S. (2007). Constructability review of surface treatments constructed on base courses, Technical Report, Report No. 0-5169-2, U.S. Department of Transportation, Virginia.
Wang, G., yi Wang, D. and ning Li, D. (2017). "Laboratory study and performance evaluation of a new type of prime coat material used on cement treated base", Construction and Building Materials, 147, 588-597.
Xu, G., Shen, W., Huo, X., Yang, Z., Wang, J., Zhang, W. and Ji, X. (2018). "Investigation on the properties of porous concrete as road base material", Construction and Building Materials, 158, 141-148.
Zhang, Q., Xu, Y.-h. and Wen, Z.-g. (2017). "Influence of water-borne epoxy resin content on performance of waterborne epoxy resin compound SBR modified emulsified asphalt for tack coat", Construction and Building Materials, 153, 774-782. | ||
|
آمار تعداد مشاهده مقاله: 234 تعداد دریافت فایل اصل مقاله: 765 |
||