پیوندهای مفید
اخبار و اعلانات
آمار
| تعداد نشریات | 161 |
| تعداد شمارهها | 6,532 |
| تعداد مقالات | 70,500 |
| تعداد مشاهده مقاله | 124,086,980 |
| تعداد دریافت فایل اصل مقاله | 97,190,163 |
Unsteady-state Computational Fluid Dynamics Modeling of Hydrogen Separation from H2/N2 Mixture | ||
| Journal of Chemical and Petroleum Engineering | ||
| مقاله 6، دوره 51، شماره 2، اسفند 2017، صفحه 135-146 اصل مقاله (904.6 K) | ||
| نوع مقاله: Research Paper | ||
| شناسه دیجیتال (DOI): 10.22059/jchpe.2017.233301.1196 | ||
| نویسندگان | ||
| Abdolmajid Sharafpoor1؛ Zahra Mansourpour* 1؛ Azadeh Ghaee2 | ||
| 1School of Chemical Engineering, College of Engineering, University of Tehran, Tehran, Iran | ||
| 2Department of life science engineering, Faculty of new sciences and technologies, University of Tehran, Tehran, Iran | ||
| چکیده | ||
| 3D modeling of Pd/α-Al2O3 hollow fiber membrane by using computational fluid dynamic for hydrogen separation from H2/N2 mixture was considered in steady and unsteady states by using the concept of characteristic time. Characteristic time concept could help us to design and calculate surface to volume ratio and membrane thickness, and adjust the feed conditions. The contribution of resistance between the membrane and the gas phase could be analyzed by considering characteristic times. The effect of temperature on quasi-steady time was examined at constant feed flow rate and pressure. As a result, when thickness of membrane was less than the critical amount, the surface resistance was important. According to the results, about 50% mass separation was obtained in the initial 8% period of permeation time. By enhancing temperature, membrane permeation and, consequently, hydrogen separation increased. The CFD results showed good agreement with experimental data. | ||
| کلیدواژهها | ||
| Hollow fiber membrane؛ Computational Fluid Dynamics؛ Hydrogen separation؛ Characteristic time؛ Unsteady state | ||
| مراجع | ||
|
[1] Baker, R.W. (2002). “Future directions of membrane gas separation technology.” Industrial & Engineering Chemistry Research, Vol. 41 (6), pp. 1393-1411.
[2] Phair, J.W. and Badwal, S.P.S. (2006). “Materials for separation membranes in hydrogen and oxygen production and future power generation.” Science and Technology of Advanced Materials, Vol. 7 (8), pp. 792-805.
[3] Basile, A. (2008). “Hydrogen production using Pd-based membrane reactors for fuel cells.” Topics in Catalysis, Vol. 51 (1-4), p. 107.
[4] Chen, W.H. and Hsu, P.C. (2011). “Hydrogen permeation measurements of Pd and Pd–Cu membranes using dynamic pressure difference method.” International Journal of Hydrogen Energy, Vol. 36 (15), pp. 9355-9366.
[5] Gallucci, F., Chiaravalloti, F., Tosti, S., Drioli, E. and Basile, A. (2007). “The effect of mixture gas on hydrogen permeation through a palladium membrane: experimental study and theoretical approach.” International Journal of Hydrogen Energy, Vol. 32 (12), pp. 1837-1845.
[6] Gao, H., Lin, Y.S., Li, Y. and Zhang, B. (2004). “Chemical stability and its improvement of palladium-based metallic membranes.” Industrial & Engineering Chemistry Research, Vol. 43 (22), pp. 6920-6930.
[7] Chen, C. H. and Ma, Y.H. (2010). “The effect of H2S on the performance of Pd and Pd/Au composite membrane.” Journal of Membrane Science, Vol. 362 (1), pp. 535-544.
[8] Tosti, S., Basile, A., Borelli, R., Borgognoni, F., Castelli, S., Fabbricino, M., Gallucci, F. and Licusati, C. (2009). “Ethanol steam reforming kinetics of a Pd–Ag membrane reactor.” International Journal of Hydrogen Energy, Vol. 34, No. 11, pp. 4747-4754.
[9] Yang, J.Y., Komaki, M. and Nishimura, C. (2007). “Effect of overlayer thickness on hydrogen permeation of Pd60Cu40/V–15Ni composite membranes.” International Journal of Hydrogen Energy, Vol. 32 (12), pp. 1820-1824.
[10] Chen, W.H., Hsia, M.H., Lin, Y. L., Chi, Y.H. and Yang, C.C. (2013). “Hydrogen permeation and recovery from H2–N2 gas mixtures by Pd membranes with high permeance.” International Journal of Hydrogen Energy, Vol. 38 (34), pp. 14730-14742.
[11] Pan, X.L., Xiong, G.X., Sheng, S.S., Stroh, N. and Brunner, H. (2001). “Thin dense Pd membranes supported on α-Al2O3 hollow fibers.” Chemical Communications, No. 24, pp. 2536-2537.
[12] Weller, S. and Steiner, W.A. (1950). “Separation of gases by fractional permeation through membranes.” Journal of Applied Physics, Vol. 21 (4), pp. 279-283.
[13] Pan, C.Y. (1983). “Gas separation by permeators with high‐flux asymmetric membranes.” AIChE Journal, Vol. 29 (4), pp. 545-552.
[14] Li, K., Acharya, D.R. and Hughes, R. (1990). “Mathematical modelling of multicomponent membrane permeators.” Journal of Membrane Science, Vol. 52 (2), pp. 205-219.
[15] Kaldis, S.P., Kapantaidakis, G.C. and Sakellaropoulos, G.P. (2000). “Simulation of multicomponent gas separation in a hollow fiber membrane by orthogonal collocation—hydrogen recovery from refinery gases.” Journal of Membrane Science, Vol. 173 (1), pp. 61-71.
[16] Takaba, H. and Nakao, S.I. (2005). “Computational fluid dynamics study on concentration polarization in H 2/CO separation membranes.” Journal of Membrane Science, Vol. 249 (1), pp. 83-88.
[17] Chen, W.H. and Hsu, P.C. (2011). “Hydrogen permeation measurements of Pd and Pd–Cu membranes using dynamic pressure difference method.” International Journal of Hydrogen Energy, Vol. 36 (15), pp. 9355-9366.
[18] Coroneo, M., Montante, G., Baschetti, M. G. and Paglianti, A. (2009). “CFD modelling of inorganic membrane modules for gas mixture separation.” Chemical Engineering Science, Vol. 64 (5), pp. 1085-1094.
[19] Dehkordi, J.A., Hosseini, S.S., Kundu, P. K. and Tan, N.R. (2016). “Mathematical Modeling of Natural Gas Separation Using Hollow Fiber Membrane Modules by Application of Finite Element Method through Statistical Analysis.” Chemical Product and Process Modeling, Vol. 11, (1), pp. 11-15.
[20] Chen, W.H., Syu, W.Z., Hung, C. I., Lin, Y.L. and Yang, C.C. (2013). “Influences of geometry and flow pattern on hydrogen separation in a Pd-based membrane tube.” International Journal of Hydrogen Energy, Vol. 38 (2), pp. 1145-1156.
[21] Wang, W.P., Thomas, S., Zhang, X.L., Pan, X.L., Yang, W.S. and Xiong, G.X. (2006). “H2/N2 gaseous mixture separation in dense Pd/α-Al2O3 hollow fiber membranes: experimental and simulation studies.” Separation and purification technology, Vol. 52 (1), pp. 177-185.
[22] Nair, B.K.R. and Harold, M.P. (2008). “Experiments and modeling of transport in composite Pd and Pd/Ag coated alumina hollow fibers.” Journal of Membrane Science, Vol. 311 (1), pp. 53-67.
[23] Caravella, A., Scura, F., Barbieri, G. and Drioli, E. (2010). “Inhibition by CO and polarization in Pd-based membranes: a novel permeation reduction coefficient.” The Journal of Physical Chemistry B, Vol. 114, (38), pp. 12264-12276.
[24] Gielens, F.C., Knibbeler, R.J.J., Duysinx, P.F.J., Tong, H.D., Vorstman, M. A.G. and Keurentjes, J. T. F. (2006). “Influence of steam and carbon dioxide on the hydrogen flux through thin Pd/Ag and Pd membranes.” Journal of Membrane Science, Vol. 279 (1), pp. 176-185. | ||
|
آمار تعداد مشاهده مقاله: 520 تعداد دریافت فایل اصل مقاله: 523 |
||